Contact Us

INQUIRY

Result Of Concrete With Sand And Saw Dust

Utilization of treated saw dust in concrete as partial ...

10-07-2020· The decrease in compressive strength of concrete containing water treated saw dust may be due to 1) weaker particles of saw dust compared to natural sand particles 2) compressible nature of saw dust particles, 3) higher actual w/c ratio as a result of release of absorbed water by spongy saw dust particles during mixing process, and 4) poor bond between saw dust particles and cement paste.

Get Price

(PDF) Partial Replacement of Sand with Sawdust in …

This study focuses on the experimental investigation of using saw-dust as a partial replacement of sand in the properties of concrete mix. Saw dust also known as wood dust is a by-product or waste ...

Get Price

Compressive Strength of Concrete Using Sawdust as Aggregate

Compressive Strength of Concrete Using Sawdust as Aggregate Daniel Yaw Osei, Emmanuel Nana Jackson Abstract—This paper reports on experimental investigations on the effect of replacing sand with sawdust on the properties of concrete. A concrete mix of 1:2:4 was used as control while sawdust was used to replace 25%, 50%, 75% and 100% of sand ...

Get Price

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL ...

concrete M -20 Mix.Th e result shows that compressive strength decreases as the saw dust pecrcentage increases .Optimum replacement of sand with saw dust was found to be 15%. Keywords -concrete,saw dust, ordinary portland cement,compressive strength 1.INTRODUCTION Concrete is nec essary in modern society's interest with

Get Price

Partial replacement of sand with sawdust - YouTube

10-06-2015· Comparison and analysis of concrete by partialy replacement of sand with saw dust.

Get Price

(PDF) IRJET- Use of Saw Dust as Fine Aggregate in Concrete ...

https://www.irjet.net/archives/V5/i9/IRJET-V5I9230.pdf

Get Price

Partial Replacement Of Sand With Sawdust In Concrete

material for partial replacement of sand in concrete for modifying its properties. In the concrete mixes sand was replaced at 5%, 10%, 15%, 20% and 25% by weight and effects of replacement on concrete is observed. Use of saw dust in concrete permits disposal of waste (saw dust) and make concrete …

Get Price

Full text of "Sawdust-cement concrete"

Full text of "Sawdust-cement concrete" See other formats i.n/m; kiLQi-fr- SAWDUST-CEi'.IENf CONCRETE By Forest Products Laboratory- Forest Service, U. S. Department of Agriculture DEPOSITORY The Forest Products Laboratory has conducted no research on the use of sawdust in mixture with cement for the production of structural concrete.

Get Price

(PDF) Stone Dust in Concrete: Effect on Compressive Strength

Results shows natural sand can be effectively replace with stone dust and maximum strength attains at 60 percent replacement of natural sand with stone dust based on compressive strength. View ...

Get Price

Building a Sawdust Concrete Home - Green Homes - …

Building a sawdust concrete home. An article reprinted from Popular Mechanics, and an update on how that house has held up, thirty years later.

Get Price

Partial Replacement Of Sand With Sawdust In Concrete

material for partial replacement of sand in concrete for modifying its properties. In the concrete mixes sand was replaced at 5%, 10%, 15%, 20% and 25% by weight and effects of replacement on concrete is observed. Use of saw dust in concrete permits disposal of waste (saw dust) and make concrete …

Get Price

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL ...

concrete M -20 Mix.Th e result shows that compressive strength decreases as the saw dust pecrcentage increases .Optimum replacement of sand with saw dust was found to be 15%. Keywords -concrete,saw dust, ordinary portland cement,compressive strength 1.INTRODUCTION Concrete is nec essary in modern society's interest with

Get Price

Utilization of treated saw dust in concrete as partial ...

Sand in concrete was replaced with 5, 10, 15 and 20% water treated saw dust. • The optimum quantity of water or sodium silicate treated saw dust is 5%. • Density of concrete decreased on use of saw dust. • Strength properties of concrete modified with 5% saw dust is comparable. • Chloride ion permeability improved on silica fume in saw ...

Get Price

Structural Characteristics of Sawdust-Sand-Cement Composite

His investigation was centered on concrete of grade 1522. He - also studied the effect of partial replacement of sand with sawdust, from these work he concluded that the best replacement is from 25From all the papers re-50%. -viewed there is no published work on the structural characteristics of sawdust-sand-cement composite, hence this paper. 2 M

Get Price

(PDF) IRJET- Use of Saw Dust as Fine Aggregate in …

https://www.irjet.net/archives/V5/i9/IRJET-V5I9230.pdf

Get Price

Saw Dust As Fine Aggregate In Concrete - cz-eu.eu

Saw Dust As Fine Aggregate In Concrete. Effect on Strength Properties of M30 Grade of . varying proportion in the concrete .The replacement of fine aggregate (sand) . concrete. SAW DUST Wooden saw dust obtained from wood cutting. Get Price And Support Online; literature review on replacement of fine aggregate by .

Get Price

Partial Replacement of Sand by Quarry Dust in Concrete

investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Get Price

Use of Saw Dust Ash as Partial Replacement for Cement In ...

Use of Saw Dust Ash as Partial Replacement for Cement In Concrete Obilade, I. O. Department of Civil Engineering, Osun State Polytechnic, Iree, Nigeria ABSTRACT : This paper presents the results of the investigation carried out on the use of Saw Dust Ash (SDA) as partial replacement for Ordinary Portland Cement (OPC) in concrete.

Get Price

665 INTERNATIONAL JOURNAL OF SCIENTIFIC & ENGINEERING ...

Utilization of Saw Dust in Cement Mortar & Cement Concrete K.GOPINATH, K.ANURATHA, R.HARISUNDAR, M.SARAVANAN ABSTRACT The use of sand (river sand) plays a major role in all type of construction, especially in cement concrete & cement mortar. The ultimate aim of the saw dust concrete is to recycle the waste material from saw mill & utilizing

Get Price

Low Cost Construction Material for Concrete as Sawdust

Ages (Days) Percentage Replacement with saw dust 10% 15% 20% Increase(+) or decrease (-) strength % 7 21.89 15.54 5.54 14 -11.85 11.12 0.437 0 5 10 15 20 25 7 DAYS 14 DAYS H 2 AGES IN DAYS 0% SAW DUST 10%SAW DUST 15% SAW DUST 20% SAW DUST Fig.2 Variation of Compressive strength with age and percentage of saw dust 0 5 10 15 20 25 0% SAW DUST 10% ...

Get Price

Partial Replacement of Sand by Quarry Dust in Concrete

investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Get Price

Partial Replacement of Cement by Saw Dust Ash in Concrete ...

saw dust ash as partial replacement of cement in concrete. Cement was replaced by Saw Dust Ash as 5%, 10%, 15% and 20% by weight for M-25 mix. The concrete specimens were tested for compressive strength, durability (water absorption) and density at 28 days of age and the results obtained were compared with those of normal concrete.

Get Price

Utilization of treated saw dust in concrete as partial ...

Sand in concrete was replaced with 5, 10, 15 and 20% water treated saw dust. • The optimum quantity of water or sodium silicate treated saw dust is 5%. • Density of concrete decreased on use of saw dust. • Strength properties of concrete modified with 5% saw dust is comparable. • Chloride ion permeability improved on silica fume in saw ...

Get Price

Use of Saw Dust Ash as Partial Replacement for Cement In ...

Use of Saw Dust Ash as Partial Replacement for Cement In Concrete Obilade, I. O. Department of Civil Engineering, Osun State Polytechnic, Iree, Nigeria ABSTRACT : This paper presents the results of the investigation carried out on the use of Saw Dust Ash (SDA) as partial replacement for Ordinary Portland Cement (OPC) in concrete.

Get Price

A Study on Strength of Concrete with Partial Replacement ...

a reduction in strength with an increment of saw dust ash. But while adding steel fibre to SDA, it is observed that the fibre reinforced saw dust ash (FRSDA) concrete has an increase in strength twice than that of the SDA concrete at 3rd, 7th and 28th days. Keywords: Saw dust ash concrete, saw dust ash, steel fibre, mix

Get Price

Saw Dust As Fine Aggregate In Concrete - cz-eu.eu

Saw Dust As Fine Aggregate In Concrete. Effect on Strength Properties of M30 Grade of . varying proportion in the concrete .The replacement of fine aggregate (sand) . concrete. SAW DUST Wooden saw dust obtained from wood cutting. Get Price And Support Online; literature review on replacement of fine aggregate by .

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF FINE ...

sand by quarry dust in hallow concrete block for different mix proportion”vol .no. s, February . []R.Mahendrana N of C.marthong “Saw dust ash as partial replacement of cement”vol..pp s { z r-1985 (2012). []Radhikesh P. nand , Amiya k.Das, Mohanrana.”Strngth crusher dust as a fine aggregatssse in concrete in concrete paving blocks”vol.,

Get Price

Light weight concrete with partial sand with wooden powder

SCOPE OF THE WORK a) Use of saw dust and by sand replacement in normal concrete for real time projects thereby reducing the overall cost of construction. b) Reduction in mining river sand helps protecting the ground water table. c) The effective way of utilising waste material leads to clean environment. 35.

Get Price

How to Control Dust When Cutting Concrete | MegaSaw

If you take longer when handling concrete cutting tasks, you will inhale more dust than the people who work for shorter times. How to Control Exposure to Concrete Dust 1. Legal requirements. There are workplace regulations in place to prevent exposure to any dust during construction.

Get Price

Sawdust, Sand and Cement - Rainforest Info

The most common mixture used for walls consists of 3 parts sawdust, 2 parts sand and 1 part cement. For smaller panels, 4 parts sawdust is usually satisfactory. The sawdust should be from hardwood - which is low in tannin, gums and oils - for the best results. Most people mix the ingredients in a large, shallow metal tray using hoes or rakes.

Get Price